Tell us about the job
Takes about a minute. No obligation.
A furnace quoted for replacement in this area has almost certainly spent most of its life running against ordinary seasonal demand, not repeated severe-weather punishment. 31 severe weather events were recorded in Gonzales County, Texas between 2015 and 2024. At that rate, severe weather is something equipment here encounters now and then, not a grind that wears components down year over year. A contractor sizing and installing a new furnace in Gonzales County is making decisions about equipment grade, duct fit, and installation quality, and those choices carry more weight here than weather hardening does. A system that fails in this county failed for reasons the install or the years of service explain.
Ductwork laid in for an older furnace was sized around what that furnace needed, and a new unit asks something different of it. Half the homes in Gonzales County, Texas were built in 1983 or earlier (2020-2024 ACS 5-year). A contractor pricing a furnace installation here has to assess whether those ducts will distribute what a new system moves before the equipment selection means anything. That assessment shapes the quote more than the unit itself does.
What Gets Installed With a New Furnace
The furnace itself sits inside the house, most often in a utility closet, basement, or garage, and it is the unit that produces heated air. Attached to it is the air handler, which pulls indoor air across the heat exchanger and pushes the warmed air into the supply side of the home's duct system.
The flue pipe runs from the furnace cabinet to an exterior wall or through the roof, carrying combustion gases out of the house. Alongside the furnace, a new thermostat goes on an interior wall and gives the homeowner direct control over when the system runs and at what temperature.
The drawing shows a typical layout, and a licensed contractor determines exactly which components apply to this house and how each one is positioned.
Get matched in Gonzales CountyGonzales County by the numbers
31 severe weather events were recorded in Gonzales County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Gonzales County, Texas were built in 1983 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesGonzales County, Texas holds 9,020 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 66.2% of the occupied homes in Gonzales County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules for Gonzales County, Texas5 sourced standards and codes
What the Installation Actually Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing Rules for HVAC Work in Gonzales County, Texas
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Severe Weather Events in Gonzales County
Weather puts a load on heating and cooling equipment, and that load shapes what a furnace here has to handle over its working life. Sizing and installing a system for Gonzales County means accounting for local conditions, not just a generic climate profile.
31 severe weather events, 2016–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.