Tell us about the job
Takes about a minute. No obligation.
A furnace quoted for replacement in DeWitt County has probably spent most of its life running against ordinary seasonal demand, not a relentless weather workload. 22 severe weather events were recorded in DeWitt County, Texas between 2015 and 2024. At that rate, severe weather is an event, not a background condition, and a contractor sizing or installing a new unit here is working around the demands of the local heating season rather than around storm exposure. What that means practically: the quality of the installation and the accuracy of the load calculation are what determine how the new system performs, because the weather record gives a contractor little reason to compensate for unusual cumulative stress.
Ductwork laid down for an earlier generation of heating equipment carries assumptions about airflow, routing, and capacity that a new furnace will test immediately. Half the homes in DeWitt County, Texas were built in 1978 or earlier (2020-2024 ACS 5-year). A contractor sizing and installing a furnace here has to assess whether the existing duct system can move the air a new unit is rated to push, and where it cannot, that work becomes part of the job before the equipment is ever set. The electrical service gets the same look, since older panels were not wired for the loads modern furnaces draw. What the house already contains sets the scope.
What Gets Installed With a New Furnace
The furnace itself sits in a utility room, basement, or closet and is the unit that produces heat for the house. A burner assembly inside it ignites the fuel, and a heat exchanger transfers that heat to the air moving through the cabinet. The blower motor, housed in the lower section of the unit, pushes that warmed air out into the home.
The flue pipe runs from the furnace to an exterior wall or the roof and carries combustion gases out of the house. A gas valve, also inside or directly behind the unit, controls fuel supply to the burners, and the thermostat on an interior wall is the control point that signals the whole system to start or stop.
The drawing shows a general layout of these components, and a licensed contractor determines exactly what applies to your house.
Get matched in DeWitt CountyDeWitt County, by the numbers
22 severe weather events were recorded in DeWitt County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in DeWitt County, Texas were built in 1978 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesDeWitt County, Texas holds 9,238 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 73.9% of the occupied homes in DeWitt County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules on the Books for DeWitt County, Texas5 codes, standards, and statutes
What happens when the contractor arrives
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in DeWitt County, Texas
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.