Tell us about the job
Takes about a minute. No obligation.
A furnace in Dallas County has been running against genuine weather pressure, not occasional rough patches. 379 severe weather events were recorded in Dallas County, Texas between 2015 and 2024. At that rate, a contractor opening a failed heat exchanger or a cracked burner assembly is working out whether the damage follows from cumulative stress on the system or from components that simply reached the end of their serviceable life. Those are different repairs, and they carry different price tags. Stress-related failures tend to show up in parts that absorb thermal swings; age failures show up more evenly. A contractor who establishes which one it is before quoting saves the homeowner from replacing parts that were not the cause.
Furnaces in houses this old have been running through Texas heat cycles for a very long time, and what a contractor finds once the cabinet is open reflects that accumulation directly. Half the homes in Dallas County, Texas were built in 1983 or earlier (2020-2024 ACS 5-year). That means a repair call here carries a real chance of turning up a cracked heat exchanger, a degraded igniter, or a limit switch that has tripped so many times its calibration has drifted. Those are parts a contractor has to inspect in person, because the symptom at the thermostat does not tell you which one gave out first.
The Parts of a Furnace a Contractor Checks First
The heat exchanger sits inside the furnace cabinet, usually in a utility closet, basement, or garage, and it is the piece that transfers heat into the air moving through your home. Cracks or failures here are a serious find. The burner assembly sits just below it and is often where a contractor starts when the furnace is not igniting or is short-cycling.
The blower motor and its wheel sit at the base of the cabinet and push conditioned air into the supply side of your duct system. The flue pipe runs from the top or back of the furnace to an exterior vent and carries combustion gases out of the house. The control board, tucked inside the cabinet door, coordinates every component and is a common point of failure when symptoms are electrical or intermittent.
The drawing shows a representative layout, and a licensed contractor determines which components apply to your specific system and how each one factors into the repair.
Get matched in Dallas CountyDallas County, by the numbers
379 severe weather events were recorded in Dallas County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Dallas County, Texas were built in 1983 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesDallas County, Texas holds 1,064,965 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 50.8% of the occupied homes in Dallas County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Repair Rules on the Books for Dallas County, Texas5 sourced standards and codes
What HVAC Repair Looks Like in Dallas County
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
What Dallas County, Texas Requires for This Work
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Weather Events in Dallas County That Put HVAC Equipment to Work
Extreme weather is load. Every spike in heat or cold forces a furnace to run harder and longer than it was built to do on a mild day. Repair frequency in Dallas County tracks with what the weather demands, which is why storm history belongs on a page about keeping heating equipment in working order.
379 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.