Tell us about the job
Takes about a minute. No obligation.
A furnace repair call in Zavala County is rarely about what the weather has put the system through. 19 severe weather events were recorded in Zavala County, Texas between 2015 and 2024. At that rate, severe weather visits this area periodically, and most residential furnaces have not been ground down by relentless storm exposure. What a contractor finds when they open a struggling unit is more likely a heat exchanger worn past its service life, a failing inducer motor, or a control board that was never installed correctly. Age and workmanship are the first things they price and address.
Ductwork and wiring in a house this old were put in for systems that no longer exist, and the furnace running in one today has almost certainly been replaced or patched at least once since. Half the homes in Zavala County, Texas were built in 1979 or earlier (2020-2024 ACS 5-year). What that history means for repair work is specific: once a contractor opens the unit, the question that decides the job is whether the components it uses still have a supply chain behind them. A heat exchanger or a control board on an older furnace can be the kind of part a contractor has to source carefully, and sometimes cannot source at all, which changes what gets repaired and what gets replaced.
The Parts of a Furnace a Contractor Checks First
The heat exchanger sits inside the furnace cabinet in the mechanical room or a closet and is the part a contractor moves to quickly when the system runs but fails to heat. The burners fire just below it, and when either piece has cracked, corroded, or fouled, the whole heating cycle breaks down.
The blower motor sits at the base of the cabinet and pushes conditioned air out through the supply side of the system. The control board and the igniter both live inside the cabinet as well. When the furnace short-cycles, refuses to start, or trips the limit switch repeatedly, those components are where a contractor looks next.
The drawing shows a general layout of the system, and a licensed contractor determines what applies to the specific equipment and configuration in your home.
Find a contractor in Zavala CountyZavala County, by the numbers
19 severe weather events were recorded in Zavala County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Zavala County, Texas were built in 1979 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesZavala County, Texas holds 3,946 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 69.0% of the occupied homes in Zavala County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards Behind Furnace Repair in Zavala County, Texas5 sourced rules & standards
What Happens When a Contractor Comes to Your Home
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in Zavala County, Texas
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.