Tell us about the job
Takes about a minute. No obligation.
A furnace repair call in Duval County starts with the system itself, not with what the sky has thrown at it. 38 severe weather events were recorded in Duval County, Texas between 2015 and 2024. At that rate, severe weather is an occasional event rather than a steady operating pressure on equipment, which means a contractor diagnosing a failed heat exchanger or a dead igniter is looking at how old the unit is, how well it was installed, and whether it has been serviced. Those are the factors that account for what gets found inside a furnace here. A weather record this light does not explain a cracked component; deferred maintenance usually does.
Furnace systems in houses this old have often run long enough that the heat exchanger, gas valve, or control board inside has no newer counterpart on a standard parts shelf. Half the homes in Duval County, Texas were built in 1980 or earlier (2020-2024 ACS 5-year). A contractor who opens a unit and identifies the fault still has to confirm the replacement part is manufactured before that repair is a viable option. When it is not, the job changes shape entirely, and what the homeowner is deciding shifts from a repair cost to a replacement decision.
The Parts of a Furnace a Contractor Checks First
The heat exchanger sits at the core of the furnace cabinet in a utility room, basement, or closet, and it is where combustion heat transfers to the air moving through your home. When it cracks or corrodes, the furnace often short-cycles or trips the limit switch. The burners sit just below it, and a contractor will pull those out early to look for uneven flame or carbon buildup.
The blower motor and its wheel sit in the lower half of the cabinet and push conditioned air out into the supply side of your duct system. The inducer motor sits near the flue collar at the top and pulls combustion gases out of the heat exchanger before they can back up. The control board ties all of it together, and a fault there can mimic failures in any of the components around it.
The drawing shows a representative layout, and a licensed contractor will determine which components and conditions apply to the specific furnace and installation in your home.
Get matched in Duval CountyDuval County, by the numbers
38 severe weather events were recorded in Duval County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Duval County, Texas were built in 1980 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesDuval County, Texas holds 4,420 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 70.4% of the occupied homes in Duval County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards Governing Furnace Repair in Duval County, Texas5 sourced rules & standards
What Happens When the Contractor Arrives
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
What Duval County, Texas Requires for This Work
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Severe Weather Events in Duval County
Extreme weather puts real hours on heating equipment. Furnaces that cycle hard through weather stress are the ones that surface faults, and knowing the local pattern is part of understanding the repair workload a furnace here actually carries.
38 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.