Tell us about the job
Takes about a minute. No obligation.
A furnace that fits Roberts County has to be sized for what the climate here actually demands of it, not for a national average. 110 severe weather events were recorded in Roberts County, Texas between 2015 and 2024. Severe weather at that rate means a heating system in this county runs under real load across a season, and a contractor quoting an install here has to account for that before settling on a unit size, duct layout, or sealing spec. A furnace installed light for the conditions will cycle harder and lose efficiency faster than one matched to what the area gets.
Older ductwork does not automatically fail a load calculation, but in a county where so much of the housing dates to an earlier era of heating technology, what is already inside the walls shapes what a contractor can and cannot do with a new furnace. Half the homes in Roberts County, Texas were built in 1966 or earlier (2020-2024 ACS 5-year). Duct systems from that period were laid out for equipment with different airflow and static pressure requirements, and a contractor quoting a furnace replacement has to assess what is there before committing to a scope. If the existing ductwork carries the new unit's output without modification, the job is straightforward. If it does not, the duct work becomes the larger part of the project than the furnace itself.
What Gets Installed With a New Furnace
The furnace itself sits in a utility room, basement, or closet and is the unit that generates heat. A burner assembly inside it ignites the fuel, and a heat exchanger transfers that heat to the air moving through the system. The flue pipe exits through a wall or roof and carries combustion gases out of the house.
The blower motor lives inside the furnace cabinet and pushes conditioned air out into the home. The air handler connects to the supply and return sides of the duct system at the furnace. A thermostat mounts on an interior wall and is the control point that tells the furnace when to fire.
The drawing shows the general layout of these components, and a licensed contractor determines exactly what applies to your house.
Find a contractor in Roberts CountyRoberts County, by the record
110 severe weather events were recorded in Roberts County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Roberts County, Texas were built in 1966 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesRoberts County, Texas holds 393 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 85.1% of the occupied homes in Roberts County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules & Codes for Roberts County, Texas5 sourced standards and regulations
What the Installation Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in Roberts County, Texas
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Severe Weather History in Roberts County
Weather events put real stress on heating equipment, from hard starts in cold snaps to sustained run times that expose weak components. A furnace sized and installed for local conditions holds up better than one that was not.
110 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.