Tell us about the job
Takes about a minute. No obligation.
A contractor quoting a furnace repair in Kerr County has to account for what the equipment has already been through before settling on a cause. 105 severe weather events were recorded in Kerr County, Texas between 2015 and 2024. At that rate, severe weather is a standing condition for systems here, not an occasional setback, and the wear it drives through a furnace shows up in heat exchangers that have cycled hard and in controls that have absorbed repeated stress loads. A contractor who skips that part of the inspection quotes a repair against incomplete information and risks missing the actual failure point.
Furnace repair in housing this old turns on one question a contractor cannot answer from the driveway: whether the parts the failed component needs are still in production. Half the homes in Kerr County, Texas were built in 1987 or earlier (2020-2024 ACS 5-year). Equipment goes through replacement cycles, and a furnace running in a house from that era has likely seen at least one. What a contractor finds inside the cabinet determines whether the repair is a parts order or a conversation about what comes next.
The Parts of a Furnace a Contractor Checks First
The furnace itself sits inside the house, most often in a basement, utility closet, or attic. Its heat exchanger is the piece a contractor looks at closely during a repair call, because cracks or failures there are what stop the system from doing its job. The burners, which fire inside that exchanger, are another early stop.
The blower motor sits within the furnace cabinet and pushes conditioned air through the house. Alongside it, the control board and the ignitor are small components that fail in ways that can look like bigger problems, so a contractor checks them before pulling anything apart. The flue pipe runs from the cabinet to the exterior and carries combustion gases out.
The drawing shows the general layout of a furnace system, and a licensed contractor determines which components are relevant in your specific home.
Find a contractor in Kerr CountyKerr County by the Numbers
105 severe weather events were recorded in Kerr County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Kerr County, Texas were built in 1987 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesKerr County, Texas holds 25,632 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 70.1% of the occupied homes in Kerr County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards Governing Furnace Repair in Kerr County, Texas5 sourced rules and standards
What Happens When the Contractor Arrives
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing Rules That Apply in Kerr County, Texas
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Severe Weather Events in Kerr County
Kerr County weather puts real stress on heating equipment, and stress over time turns into repair calls. That pattern makes local climate history relevant to any conversation about furnace condition.
105 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.