Tell us about the job
Takes about a minute. No obligation.
A furnace failing in Madison County is almost always failing for reasons a contractor finds inside the unit, not outside it. 40 severe weather events were recorded in Madison County, Texas between 2015 and 2024. At that rate, severe weather is an event here, not a standing pressure on the system, and a contractor quoting a replacement or a new install has to account for that. Heat exchangers crack from age and poor airflow. Flue connections fail from an install that was never quite right. The weather record in this county does not carry enough weight to be the first explanation a contractor reaches for.
Ductwork laid down for an older generation of equipment carries assumptions about airflow, sizing, and layout that a new furnace may not share. Half the homes in Madison County, Texas were built in 1985 or earlier (2020-2024 ACS 5-year). A contractor assessing an installation here will open registers, check trunk lines, and measure what the existing runs can actually move before pricing the unit itself. If the ductwork cannot carry the new system's output, it gets modified or replaced, and that work sets the scope. The furnace is straightforward to specify once the distribution side is settled.
What Gets Installed With a New Furnace
The furnace itself sits in a utility room, basement, or closet and is the unit a homeowner sees most clearly. Inside it, a heat exchanger warms the air that moves through the house, and a blower pushes that air out. A new install puts all of that in place as a fixed, connected unit.
The flue pipe runs from the furnace to an exterior wall or roofline and carries combustion gases out of the house. A gas valve and a control board also come with the unit. The thermostat, mounted on an interior wall, is the interface that tells the whole system when to run.
The drawing shows a typical layout, and a licensed contractor determines what fits and what applies in your specific home.
Find a contractor in Madison CountyMadison County by the Numbers
40 severe weather events were recorded in Madison County, Texas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Madison County, Texas were built in 1985 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesMadison County, Texas holds 5,107 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 75.3% of the occupied homes in Madison County, Texas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules on the Books for Madison County, Texas5 codes & standards
What the Installation Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
What Texas and Madison County Require for HVAC Installation
In Texas a person may not engage in air conditioning and refrigeration contracting unless that person holds a license issued under the state air conditioning and refrigeration contractor law.
Severe Weather Events in Madison County
Weather puts hours on HVAC equipment. The more a furnace is pushed through temperature swings and storm-driven cold, the more that installation quality and equipment sizing matter for a home in this area.
40 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.